电阻应变式位移传感器电路设计与实现
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

TN721.1

基金项目:

国家重大科技专项02专题(2009ZX02205)


Design and implement of resistance strain displacement sensor circuit
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    超精密平台中使用压电陶瓷驱动器提供位移进给,采用集成应变式位移传感器的驱动器能够减小磁滞与蠕变特性,提高位移控制精度。设计并实现应变式位移传感器位移检测电路,介绍电阻应变式位移传感器位移测量原理;设计位移传感器电路,采用仪表放大器、同相衰减器与低通滤波器电路得到正比于位移变化的电压信号并输出;最后对位移传感器电路进行实验验证。实验结果表明:设计的传感器检测电路的电噪声峰峰值为0.390 mV,输出电压分辨率小于0.6 mV,对应的位移传感器的分辨可达1 nm,能够有效提高压电陶瓷的精度。

    Abstract:

    Ultraprecision platform uses piezoelectric ceramic drivers to provide displacement feed. Strain gauge displacement sensor integrated drivers can be used to reduce the hysteresis and creep characteristics and improve precision of the displacement control. This paper designs and implements the displacement measuring circuit for the strain displacement sensor. The measurement principle of the resistance strain displacement sensor is introduced. Then, the displacement sensor circuit is designed, using instrumentation amplifier inphase attenuator and lowpass filter to obtain and output voltage signal that proportional to displacement change. Finally, the experiments of the displacement sensor circuit are carried out. The experiment results indicate that the electronic noise of the sensor circuit is 0.390 mV (peaktopeak value), and the resolution of the output voltage is less than 0.6 mV, the corresponding displacement resolution is up to 1 nm, which can effectively improve the precision of the piezoelectric ceramic.

    参考文献
    相似文献
    引证文献
引用本文

葛川 李朋志 徐立松 李佩玥.电阻应变式位移传感器电路设计与实现[J].国外电子测量技术,2015,34(6):58-61

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2015-09-28
  • 出版日期: